NEWS:   GM recalls 250K vehicles; seat belts may not latch

YAHOO NEWS -- August 17, 2010 – General Motors is recalling nearly 250,000 crossover vehicles worldwide to inspect second-row seat belts that could be damaged and not latch.

GM says the recall affects 2009-2010 models of the Chevrolet Traverse, Buick Enclave, GMC Acadia and Saturn Outlook.

Most of the recalled vehicles are in the United States but some are also in Canada, Mexico and elsewhere.

GM says the seat belt buckle could be damaged when the seat back is returned to an upright position. That could make the buckle appear to latch when it isn't.

The automaker says it does not know of any cases where the second-row seat belts failed to perform properly in a crash.

MORE RECALL INFO

• Chevrolet Traverse
• Buick Enclave
• GMC Acadia
• Saturn Outlook

NEWS:   GM recalling 1.5M vehicles over fire concerns

YAHOO NEWS – June 8, 2010 – General Motors Co. said Tuesday it was recalling about 1.5 million vehicles worldwide to address a problem with a heated windshield wiper fluid system that could lead to a fire, its second recall over the issue in two years.

The recall affects several pickup trucks, sport utility vehicles, crossovers and passenger car models from the 2006 to 2009 model years. GM conducted a similar recall in 2008 but came across new reports of fires in vehicles that had been fixed.

GM said it would disable the heated washer fluid system module that could lead to fires. The Detroit automaker will pay owners and those leasing vehicles $100 each since the feature is being disabled.

GM said it was aware of five fires but there had been no injuries or crashes reported. Nearly 1.4 million vehicles are in the U.S. and more than 100,000 vehicles are in Canada, Mexico and other international markets.

"While our analysis shows the number of incidents is very small compared with the number of vehicles on the road, we want our customers to have complete peace of mind," said Jeff Boyer, GM's executive director of safety.

The recall covers the 2006-2009 model year Buick Lucerne, Cadillac DTS, and Hummer H2; 2008-2009 Buick Enclave and Cadillac CTS; 2007-2009 Cadillac Escalade, Escalade ESV and Escalade EXT; 2007-2009 Chevrolet Avalanche, Silverado, Suburban and Tahoe; 2007-2009 GMC Acadia, Sierra, Yukon and Yukon XL; 2007-2009 Saturn Outlook; and 2009 Chevrolet Traverse.

The auto company said customers will begin to receive recall letters later this month but can contact their dealer to make an appointment to have the heated washer system removed. Dealers will remove the heated washer fluid module and reroute washer fluid hoses.

GM said the technology was available from only one supplier, Microheat Inc., of Farmington Hills, Mich., which went out of business, preventing GM from working with another supplier on an improved design.

GM recalled more than 900,000 vehicles because of the heated washer fluid system in August 2008 because a short circuit on the circuit board could overheat the ground wire. The National Highway Traffic Safety Administration had opened an investigation in February 2008 into 2007 Yukon and Tahoe vehicles over potential engine compartment fires.

The government closed its investigation after the 2008 recall but GM later came across fires in vehicles that had been fixed under the previous recall, prompting the latest safety action.

MORE RECALL INFO

• Buick Enclave
• Buick Lucerne
• Cadillac CTS
• Cadillac DTS
• Cadillac Escalade, ESV and EXT
• Chevrolet Avalanche
• Chevrolet Silverado
• Chevrolet Suburban
• Chevrolet Tahoe
• Chevrolet Traverse
• GMC Acadia
• GMC Sierra
• GMC Yukon and Yukon XL
• Hummer H2
• Saturn Outlook

OCTOBER 2009 -- General Motors is recalling certain model year 2006 Chevrolet cobalt and Saturn Ion vehicles originally sold in or currently registered in the states of Arizona and Nevada; and model year 2007 Chevrolet cobalt, Pontiac G5 and Saturn ion vehicles originally sold in or currently registered in the states of Arizona, California, Florida, Nevada and Texas. The plastic supply or return port on the modular reservoir assembly may crack. If either of these ports develops a crack, fuel will leak from the area. If the crack becomes large enough, fuel may be observed dripping onto the ground and vehicle performance may be affected. Fuel leakage, in the presence of an ignition source, could result in a fire. Dealers will replace the fuel pump module free of charge. A special coverage will be implemented in the same time frame for model year 2006 vehicles registered in Alabama, Arkansas, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, North Carolina, New Mexico, Oklahoma, South Carolina, Tennessee and Texas and model year 2007 vehicles registered in: Alabama, Arkansas, Georgia, Hawaii, Louisiana, Mississippi, north Carolina, New Mexico, Oklahoma, South Carolina and Tennessee. The manufacturer has not yet provided an owner notification schedule.  09V-419

JUNE 2009 -- GM is recalling 44,451 MY 2008 Saturn VUE vehicles with body color outside door handles. The outside door handles may stick or bind. If this were to occur, the door may not latch when closed. Driving with an unlatched door could result in an unbelted occupant falling out of the vehicle, causing increased risk of injury. Dealers will replace the outside door handles with chrome door handles free of charge. The recall is expected to begin on or before August 18, 2009.  09V-233

MARCH 2009 -- General Motors is recalling 276,729 MY 2009 Buick Enclave, Chevrolet Cobalt, HHR, Malibu, Traverse, GMC Acadia, Pontiac G5, G6 and Saturn Aura and Outlook passenger vehicles. These vehicles fail to comply with Federal Motor Vehicles Safety Standard 102, "Transmission Shift Position Sequence, Starter Interlock, And Transmission Braking Effect", and FMVSS 114, "Theft Protection and RollawayPrevention". On some of these vehicles, the transmission shift cable adjustment clip may not be fullyengaged. If the clip is not fully engaged, the shift lever and the actual position of the transmission gear may not match. With this condition, the drive could move the shifter to "park" and remove the ignition key, but the transmission gear may not be in "park". The driver may not be able to restart the vehicle and the vehicle could roll away after the driver has exited the vehicle, resulting in a possible crash without prior warning. Dealers will inspect and ensure that the shift cable adjustment clip is fully engaged. In theevent that the clip does not engage, the shift cable will be replaced free of charge. The recall is expected to begin on or before March 24, 2009. Owners may contact Buick at 1-866-608-8080, Chevrolet at 1- 800-630-2438, GMC at 1-866-996-9463, Pontiac at 1-800-620-7668 and Saturn at 1-800-972-8876 or at WWW.GMOWNERCENTER.COM.   09V-073

NEWS:    GM recalling vehicles to fix shift lever problem

WASHINGTON (AP) — General Motors Corp. is recalling about 277,000 vehicles because of a potential defect in the shift lever that could cause a vehicle to roll away.

GM says the recall involves 2009 model year versions of the Buick Enclave; Chevrolet Cobalt, HHR, Malibu and Traverse; GMC Acadia; Pontiac G5 and G6; and the Saturn Aura and Outlook.

A GM spokeswoman says about 75,000 vehicles have been purchased. The rest are at dealerships. No crashes or injuries have been reported.

In some cases, the shift lever and the transmission gear's position may not match, meaning a driver could move the shifter to the park position but the transmission gear may not be in park.

A vehicle could roll away and crash or have problems restarting

MORE RECALL INFORMATION

• Buick Enclave
• Chevrolet Cobalt

• Chevrolet HHR

• Chevrolet Malibu

• Chevrolet Traverse
• GMC Acadia

• Pontiac G5

• Pontiac G6

• Saturn Aura

• Saturn Outlook

NOVEMBER  2008 -- GM is recalling 16,667 MY 2009 Buick Enclave, Chevrolet Traverse, GMC Acadia, and Saturn Outlook vehicles for failing to conform with the requirements of Federal Motor Vehicle Safety Standard No. 209, 'Seat Belt Assemblies.' These vehicles may have been built with a safety belt buckle in the second or third row that is missing a rivet. In a vehicle crash, if the rivet is missing, the buckle may separate from the mounting strap, increasing the risk of injury to the passenger. Dealers will inspect the safety belt buckles in the second and third rows, and replace them if necessary. The recall began on November 26, 2008.  08V615

AUGUST 2008 -- GM is recalling 857,735 MY 2006-2008 Buick Lucerne; Cadillac DTS; Hummer H2; MY 2007-2008 Cadillac Escalade, Escalade ESV, Escalade EXT; Chevrolet Avalanche, Silverado, Suburban, Tahoe; GMC Acadia, Sierra, Yukon, Yukon XL, Saturn Outlook; and MY 2008 Buick Enclave vehicles equipped with a heated wiper washer fluid system. A short circuit on the printed circuit board for the washer fluid heater may overheat the control-circuit ground wire. This may cause other electrical features to malfunction, create an odor, or cause smoke increasing the risk of a fire. Dealers will install a wire harness with an in-line fuse free of charge. The manufacturer has not yet provided an owner notification schedule.  08V441

AUGUST 2008 -- GM is recalling 88,809 MY 2008 Buick Enclave, and MY 2007-2008 GMC Acadia and Saturn Outlook vehicles currently or previously registered in the following states: Alaska, Colorado, Connecticut, Delaware, Idaho, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Montana, Nebraska, New Hampshire, New Jersey, New York, North Dakota, Ohio, Pennsylvania, Rhode Island, South Dakota, Utah, Vermont, West Virginia, Wisconsin, Wyoming, and the District of Columbia. If a buildup of snow or ice on the windshield or on the wipers restricts the movement of the wiper arm, the windshield wiper linkage may become detached from the motor shaft and the wipers may become inoperative. If this were to occur, driver visibility could be reduced, which could result in a vehicle crash. Dealers will install a new wiper crank arm, driver's side link, and a crank arm nut. The recall is expected to begin during October 2008.  08V-410

DECEMBER 2007 -- GM is recalling 275,936 MY 2005-2007 Cadillac CTS, SRX, STS, MY 2006-2007 Pontiac Solstice, and MY 2007 Saturn Sky passenger vehicles. The rear axle pinion seal does not meet all of the specifications and may experience a fluid leak. A rear differential failure may cause loss of motive power and possibly loss of vehicle control increasing the risk of a crash. Dealers will replace the pinion seal. The recall is expected to begin during February 2008. 07V-589

NOVEMBER 2007 -- GM is recalling 20,514 MY 2001 Saturn L-Series passenger vehicles equipped with a 2.2L 4-cylinder engine. Links in the engine’s timing chain can separate. An elevated rate of engine timing chain link separation has occurred. If a timing chain link separates while the engine is running, the engine will stall and will not restart increasing the risk of a crash. Dealers will replace the timing chain. The recall is expected to begin during January 2008. This recall was the subject of an Engineering Analysis, EA06-009, conducted by the Office of Defects Investigation. 07V519

SEPTEMBER 2007 -- GM is recalling 531 MY 2008 Pontiac Solstice and Saturn Sky passenger vehicles for failing to comply with the requirements of Federal Motor Vehicle Safety Standard No. 207, "Seating Systems." and Standard No. 210, "Seat Belt Assembly Anchorages." These vehicles may have one to four inboard seat stud fasteners that do not meet strength specification. In the event of a crash, the seat and seat belt assembly may not restrain the occupant as intended and could result in injury to the occupant. Dealers will inspect the inboard seat studs and, if necessary, remove the stud and install a bolt. The recall is expected to begin on or about October 10, 2007. 07V-454

NEWS:   GM recalls 42,408 Saturn Vues; fluid leak possible

DETROIT, Sept 19 (Reuters) - General Motors Corp (GM.N: Quote, Profile, Research, Stock Buzz) is recalling about 42,408 Saturn Vue compact SUVs built from February to July due to a potential leak of power steering fluid that could cause a fire, it said on Friday.

GM said there were four reports of minor fires in the engine compartment due to fluid coming in contact with the exhaust system, but no reports of accidents or injuries.

The report covers a tube nut that could have loosened on a group of Saturn Vues from the 2008 and 2009 model years that are equipped with six-cylinder engines.

GM said dealers would inspect and tighten the nut and check the fluid level as needed. The recall is expected to begin Sept. 26, according to the National Highway Traffic Safety Administration.

MORE RECALL INFORMATION:     Saturn Vue

NEWS:    GM recalls 944,000 vehicles for fire hazard

Recall involves vehicles that are equipped with windshield washer fluid heaters.

NEW YORK (CNNMoney.com) -- August 28, 2008 -- General Motors is recalling 944,000 vehicles, 850,000 of them in the United States, because of the potential for a fire in the vehicles' heated windshield washer fluid system.

A short circuit in the circuit board that controls the system could cause a grounding wire to overheat. That could lead to smoke and the malfunctioning of other electrical components, GM (GM, Fortune 500) said in a letter to the National Highway Traffic Safety Administration (NHTSA). In rare cases, it could cause a fire, GM said.

GM is aware of three fires caused by this problem, two of which were in the company's own test fleet vehicles, GM spokesman Tom Wilkinson said. The company is not aware of any injuries caused by the problem.

The vehicles must be turned on for the short circuit to occur, Wilkinson said, but he could not say whether the washer fluid heating system needed to be in use.

The models listed below, if they're equipped with a heated windshield washer fluid system, are subject to the recall:

The fluid heating system is a popular option on many of GM's large cars and SUVs, said Wilkinson.

On cold days, the system heats windshield washer fluid before spraying it onto the windshield, where it can melt ice and frost on the windshield.

To fix the problem, dealers will install a fuse that will shut off the system in the event of a short circuit. GM has not yet provided NHTSA with a schedule detailing when owners of affected vehicles will be notified.

MORE RECALL INFORMATION:

• Buick Lucerne

• Buick Enclave

• Cadillac DTS

• Cadillac Escalade

• Chevrolet Avalanche

• Chevrolet Silverado

• Chevrolet Suburban

• Chevrolet Tahoe

• GMC Acadia

• GMC Sierra

• GMC Yukon

• Saturn Outlook

NEWS:    GM Recalls Buicks, GMCs, Saturns to Fix Wipers

ConsumerAffairs.com -- August 28, 2008 -- General Motors is recalling 88,809 of the 2008 Buick Enclaves, 2007 to 2008 GMC Acadias and Saturn Outlooks to repair the windshield wipers.

The recall involves GM vehicles currently or previously registered in Alaska, Colorado, Connecticut, Delaware, Idaho, Illinois, Indiana, Iowa Maine, Maryland, Massachusetts, Michigan, Minnesota, Montana, Nebraska, New Hampshire, New Jersey, New York, North Dakota, Ohio, Pennsylvania, Rhode Island, South Dakota, Utah, Vermont, West Virginia, Wisconsin, Wyoming, and the District of Columbia.

The buildup of snow or ice on the windshield or wipers could restrict the movement of the wiper arm, according to the National Highway Traffic Administration (NHTSA) Web site.

"The wiper link may become detached from the motor shaft and the wipers many become inoperative," the safety agency warned, causing poor visibility and perhaps resulting in a crash.

GM dealers will install new parts required to remedy the windshield wiper defect when the recall gets underway in October.

Consumers can contact Buick at 1-866-608-8080, GMC at 1-866-996-9463, and Saturn at 1-800- 972-8876.

More Recall Information: 

Buick Enclave

GMC Acadia

Saturn Outlook

NEWS:   GM recalls pickups, SUVs , Saturns

Detroit Free Press -- November 20, 2007 --  General Motors Corp. recalled 69,000 Chevrolet, GMC and Pontiac pickups and SUVs and more than 20,000 Saturn cars for repairs including adding interior safety foam and fixing a timing chain.

In 2.2-liter, four-cylinder versions of the Saturn cars, GM will replace the engine's timing chain, which could separate while the motor is running and boost the chance of a crash. For 8.1-liter, eight-cylinder versions of the Silverado and Sierra, GM will replace the crankshaft position sensor, which can fail and stall the engine.

The recall by the world's largest automaker covers 57,100 Chevrolet Equinox and Pontiac Torrent SUVs from the 2007 model year, and 11,974 2001-model Chevy Silverado and GMC Sierra trucks and 20,514 Saturn L-Series cars, the U.S. National Highway Traffic Safety Administration said on its Web site.

GM will install extra foam in the windshield pillars of the Equinox and Torrent SUVs that aren't equipped with roof air bags or a sunroof, to lessen the risk of head injury during a crash, according to the NHTSA.

NEWS:   Toyota and GM recall 662,000 cars in U.S.

DETROIT (Reuters) - April 10, 2008 - Toyota Motor Corp and General Motors Corp are recalling more than 662,000 vehicles sold in the United States due to defects in power windows, the two companies said on Wednesday.

Toyota will recall 539,500 Corolla and Matrix vehicles for the 2003 and 2004 model years, it said in a statement.

GM said it would recall 122,598 Pontiac Vibe hatchbacks, which share the same platform with Toyota's Matrix and are built by GM in a joint venture with the Japanese automaker.

On vehicles equipped with power windows, the driver and front passenger glass bolts may loosen and cause the door glass to separate from the window regulator, Toyota said. Vehicles equipped with manual windows are not subject to the recall.

Toyota will notify vehicle owners by mail, beginning in late April. It advised owners to contact their local Toyota dealer for inspection and repairs.

Replacement of the driver and front passenger door glass bolts will be done at no charge, Toyota said.

MORE RECALL INFO:    Pontiac Vibe    Toyota Matrix    Toyota Corolla